汤有富;汪泉;朱恺波;程扬帆;宫婕;
TANG You-fu;WANG Quan;ZHU Kai-bo;CHENG Yang-fan;GONG Jie;School of Chemical Engineering, Anhui University of Science and Technology;Postdoctoral Mobile Research Station for Civil Engineering,Anhui University of Science and Technology;

• 1:安徽理工大学化学工程学院
• 2:安徽理工大学土木工程博士后流动站

摘要(Abstract)：

为了探讨水下毫秒延时起爆对爆炸振动信号的影响,在小型圆筒形爆炸水池(直径5.5m、高3.62m)中进行单药包和双药包两种形式爆炸实验。使用UBOX-5016测振仪采集爆炸振动信号,并对采集到的水下爆炸振动信号进行HHT分析。结果表明,随着测试距离的增加,振动速度减小而主振频率增大,装药量增加,振速增大;通过Hilbert能量谱、边际谱分析可知,水下爆炸振动能量的频率基本分布在100Hz以下的低频区,且主要分布于50Hz内;主振频带在3¹0Hz范围内;分别通过对能量谱、边际谱的分析,进一步验证了延时起爆能够降低水下爆炸振动能量,减小振动效应。实验结果与分析对水工建筑结构抗震设计及水下军事对抗防护等方面具有一定参考意义。
In order to investigate the effect of underwater millisecond delay initiation on the explosion vibration signals,explosive tests with single charge and double charges were carried out in the small cylindrical explosive pool(diameter 5.5 mand height 3.62m).The explosion vibration signal was collected by UBOX-5016 and the HHT analysis of the collected underwater explosion vibration signals were carried out.The result showed that the vibration velocity decreased and the vibration frequency increased with the increase of the test distance.The velocity increased with the charge quantity added.The frequency of the underwater explosion vibration energy was basically distributed in the low frequency region below 100 Hz and was mainly distributed in 50 Hz.The main vibration frequency band was in the range of 310Hz范围内;分别通过对能量谱、边际谱的分析,进一步验证了延时起爆能够降低水下爆炸振动能量,减小振动效应。实验结果与分析对水工建筑结构抗震设计及水下军事对抗防护等方面具有一定参考意义。
In order to investigate the effect of underwater millisecond delay initiation on the explosion vibration signals,explosive tests with single charge and double charges were carried out in the small cylindrical explosive pool(diameter 5.5 mand height 3.62m).The explosion vibration signal was collected by UBOX-5016 and the HHT analysis of the collected underwater explosion vibration signals were carried out.The result showed that the vibration velocity decreased and the vibration frequency increased with the increase of the test distance.The velocity increased with the charge quantity added.The frequency of the underwater explosion vibration energy was basically distributed in the low frequency region below 100 Hz and was mainly distributed in 50 Hz.The main vibration frequency band was in the range of 3¹0Hz.Through the analysis of energy spectrum and marginal spectrum,it was further verified that the delay initiation could reduce the energy of underwater explosion vibration and reduce the vibration effect.The experimental results and analysis have some significance to a seismic design of hydraulic structures and the protection of underwater military confrontation.

关键词(KeyWords)： 爆炸力学;爆炸振动;希尔伯特-黄变换;振动效应
mechanics of explosion;explosion vibration;Hilbert-Huang Transform(HHT);vibration effect

Abstract:

Keywords:

基金项目(Foundation): 国家自然基金资助项目(11502001);; 中国博士后面上资助项目(2014M561808);; 安徽省高校自然科学研究重点资助项目(KJ2014A065)

作者(Authors): 汤有富;汪泉;朱恺波;程扬帆;宫婕;
TANG You-fu;WANG Quan;ZHU Kai-bo;CHENG Yang-fan;GONG Jie;School of Chemical Engineering, Anhui University of Science and Technology;Postdoctoral Mobile Research Station for Civil Engineering,Anhui University of Science and Technology;

参考文献(References)：

• [1]PAI P F.Nonlinear vibration characterization by signal decomposition[J].Journal of Sound and Vibration,2007,307(3):527-544.
• [2]HUANG N E,SHEN Z,LONG S R.A new view of nonlinear water waves:The hilbert spectrum[J].Annual Review of Fluid Me-chanics,1999,31(1):417-457.
• [3]张义平.爆破震动信号的HHT分析与应用研究[D].长沙:中南大学,2006.ZHANG Y P.HHT analysis of blasting vibration and its application[D].Changsha:Middle and Southern University,2006.
• [4]HUANG N E,SHEN Z,LONG S R,et al.The empirical mode decomposition and the Hilbert spectrum for nonlinear and non-stationary time series analysis[C]//Proceedings of the royal society of London A:Mathematical,physical and engineering sciences.London:The Royal Society,1998,454(1971):903-995.
• [5]PENG Z K,PETER W T,CHU F L.An improved Hilbert-Huang transform and its application in vibration signal analysis[J].Journal of Sound and Vibration,2005,286(1):187-205.
• [6]张义平,李夕兵,赵国彦,等.基于HHT方法的硐室大爆破震动分析[J].岩石力学与工程学报,2006,37(1):150-154.ZHANG Y P,LI X B,ZHAO G Y,et al.Analysis of chamber blasting vibration based on HHT method[J].Chinese Journal of Rock Mechanics and Engineering,2006,37(1):150-154.
• [7]钱守一,李启月.微差爆破实际延迟时间的HHT瞬时能量识别法[J].矿业研究与开发,2012,32(2):113-116.QIAN S Y,LI Q Y.HHT instantaneous energy method to identify of delay time in millisecond blasting[J].Mining Research and Development,2012,32(2):113-116.
• [8]龚敏,邱燚可可,孟祥栋,等.基于HHT的雷管实际延时识别法在城市环境延时爆破中的应用[J].振动与冲击,2015,34(10):206-212.GONG M,QIU Y K K,MENG X D,et al.Identification method of detonator's actual firing time delay based on HHT and its application in millisecond blasting under urban environment[J].Journal of Vibration and Shock,2015,34(10):206-212.
• [9]凌同华,李夕兵,王桂尧.爆破震动灾害主动控制方法研究[J].岩土力学,2007,28(7):1 439-1 442.LING T H,LI X B,WANG G Y.A study on initiative control of blast vibration damages[J].Rock and Soil Mechanics,2007,28(7):1 439-1 442.
• [10]贾虎,郑伟花,罗强.基于HHT的金属导爆索水下爆炸信号时频特性研究[J].工程爆破,2015,21(3):5-8.JIA H,ZHENG W H,LUO Q.The characteristics of time frequency signal based on HHT in underwater explosion by metal detonating cord[J].Engineering Blasting,2015,21(3):5-8.
• [11]徐振洋,杨军,陈占扬,等.爆破地震波能量分布研究[J].振动与冲击,2014,33(11):38-42.XU Z Y,YANG J,CHEN Z Y,et al.Blasting seismic waves energy distribution based on EEMD[J].Journal of Vibration and Shock,2014,33(11):38-42.
• [12]国家安全生产监督管理总局.爆破安全规程:GB 6722-2014[S].北京:中国标准出版社,2014.State Administration of Work Safety.Safety regulations for blasting:GB 6722-2014[S].Beijing:China Standards Press,2014.