万嘉辉;赵凯;吴建国;史涛宁;马宏昊;刘凯;姚象洋;
WAN Jia-hui;ZHAO Kai;WU Jian-guo;SHI Tao-ning;MA Hong-hao;LIU Kai;YAO Xiang-yang;NO.5 Engineering Corporation Limited of CR21G;CAS Key Laboratory of Mechanical Behavior and Design of Materials (LMBD), University of Science and Technology of China;State Key Laboratory of Fire Science, University of Science and Technology of China;

• 1:中铁二十一局集团第五工程有限公司
• 2:中国科学技术大学中国科学院材料力学行为和设计重点实验室
• 3:中国科学技术大学火灾科学国家重点实验室

摘要(Abstract)：

为了分析爆破振动对新浇混凝土的影响,分别在混凝土模型浇筑后3、5、7、9、11 h进行爆破振动,通过声速仪对爆破前后混凝土的声速变化进行测量记录,同时在混凝土表面不同位置安装振动传感器用于测量振动幅值。结果表明:在爆源参数保持不变情况下,同一测点上的振动峰值随着凝固时间增加逐渐变大,说明混凝土在强度增长初期对爆破振动响应比较弱,随着水化反应进行,混凝土强度逐渐增长,其对爆破振动响应逐渐增强。另外,对于新浇筑混凝土,其内部有大量未水化水泥,即使在爆破振动作用下造成轻微的损伤,也能够完全愈合,而不影响后期强度,甚至强度因振捣作用有所提高,但也容易出现骨料下沉,导致底部强度高于上部。上述结果可为新浇混凝土在爆破振动下的安全标准提供参考。
In order to analyze the influence of blasting vibration on fresh concrete, the blasting disturbances were performed after the concrete models were produced 3, 5, 7, 9, 11 h respectively. The sound velocity of concrete was measured and recorded by a sound velocity meter before and after blasting, and the vibration amplitude was measured by the vibration sensors at different positions of the concrete surface. The results show that the vibration peak value grows with the increase of solidification time under the same vibration source parameters. At the initial stage of strength growth, the response of concrete to blasting vibration is relatively weak. With the hydration reaction, the strength and vibration response of concrete increases gradually. For fresh concrete, there is a large amount of unhydrated cement inside. Therefore even if blasting vibration causes slight damage, it can be completely healed without affecting the later strength. On the other hand, the blasting vibration may even cause coarse aggregate submerged, which will lead to the strength of concrete at the bottom exceeds that at the top. The results could provide reference for improving safety standards of concrete under blasting vibration.

关键词(KeyWords)： 新浇筑混凝土;爆破振动;声速测量;水化反应;强度
fresh concrete;blasting vibration;acoustic velocity measurement;hydration reaction;strength

Abstract:

Keywords:

基金项目(Foundation): 中国铁建股份有限公司科技研究开发课题资助项目(15-C77)

作者(Authors): 万嘉辉;赵凯;吴建国;史涛宁;马宏昊;刘凯;姚象洋;
WAN Jia-hui;ZHAO Kai;WU Jian-guo;SHI Tao-ning;MA Hong-hao;LIU Kai;YAO Xiang-yang;NO.5 Engineering Corporation Limited of CR21G;CAS Key Laboratory of Mechanical Behavior and Design of Materials (LMBD), University of Science and Technology of China;State Key Laboratory of Fire Science, University of Science and Technology of China;

DOI: 10.19931/j.EB.20200028

参考文献(References)：

• [1] 卢文波，陈明.爆破震动作用下新浇基础混凝土的安全震动速度研究[J].长江科学院院报，2003(S1):8-10,14.LU W B,CHEN M.Study on safety vibration velocity caused by blasting for fresh placing foundation concrete [J].Journal of Yangtze River Scientific Research Institute,2003(S1):8-10,14.
• [2] 陈明，卢文波.超早期混凝土爆破安全振动速度的讨论[J].工程爆破，2006(2):79-81,78.CHEN M,LU W B.Safery vibration velocity of fresh concrete under blasting vibration[J].Engineering Blasting,2006(2):79-81,78.
• [3] HULSHIZER A J.Acceptable shock and vibration limits for freshly placed and maturing concrete[J].Materials Journal,1996,93(6):524-533.
• [4] 娄建武，徐全军，龙源.影响核岛新浇混凝土强度的爆破振动速度阈值研究[J].世界地震工程，2003(2):163-167.LOU J W,XU Q J,LONG Y.Research on threshold for influence of blasting vibration velocity over the fresh concrete quality of the nuclear power station [J].World Earthquake Engineering,2003(2):163-167.
• [5] 金贤玉.早龄期混凝土试验研究及损伤分析与模糊评价[D].杭州：浙江大学，1997.JIN L Y.The damage analysis and fuzzy evaluation for early-age concrete [D].Hangzhou:Zhejiang University,1997.
• [6] DUNHAM M R,RUSH A S,HANSON J H.Effects of induced vibrations on early age concrete[J].Journal of Performance of Constructed Facilities,2007,21(3):179-184.
• [7] 魏建军，邢姣秀，徐建成.早期振动对混凝土抗拉性能影响[J].公路交通科技，2011,28(1):96-99.WEI J J,XING J X,XU J C.Effect of vibrations at early concrete ages on concrete tensile strengt[J].Journal of Highway and Transportation Research and Development,2011,28(1):96-99.
• [8] 褚怀保，吴礼报，杨小林.振动荷载作用对新浇混凝土强度与耐久性影响试验研究[J].硅酸盐通报，2018,37(9):2 919-2 923.CHU H B,WU L B,YANG X L.Experimental study on the influence of vibration load on the strength and durability of new concrete[J].Bulletin of the Chinese Society,2018,37(9):2 919-2 923.
• [9] 吴帅峰，王戈，袁东凯，等.爆破振动对新浇混凝土影响的试验研究[J].振动与冲击，2017,36(2):39-44,88.WU S F,WANG G,YUAN D K,et al.Experimental study on the influence of blasting vibration on fresh concrete [J].Journal of Vibration and Shock,2017,36(2):39-44,88.
• [10] 杨小林，刘宝，吴礼报.振动荷载作用下新浇混凝土损伤累积规律试验研究[J].混凝土，2020(9):27-30,36.YANG X L,LIU B,WU L B.Experimental research on damage accumulation law of new concrete with blasting vibration[J].Concrete,2020(9):27-30,36.
• [11] ISSA M A.Investigation of cracking in concrete bridge decks at early ages[J].Journal of Bridge Engineering,1999,4(2):116-124.
• [12] MAMLOUK M S,ZANIEWSKI J P.Materials for civil and construction engineers[M].Upper Saddle River,NJ:Pearson Prentice Hall,2006.
• [13] BASTIAN C E.The effect of vibrations on freshly poured concrete[J].Foundation Facts,1970,6(1):14-17.