赵铁军;姜殿科;周明;高蔚;闫鸿浩;
ZHAO Tie-jun;JIANG Dian-ke;ZHOU Ming;GAO Wei;YAN Hong-hao;Department of Engineering Mechanics,Dalian University of Technology;State Grid Liaoning Electric Power Supply Co.,Ltd.,Dalian Power Supply Company;

• 1:大连理工大学工程力学系
• 2:国家电网公司辽宁省电力有限公司大连供电公司

摘要(Abstract)：

为了解周边孔爆破对控制爆破振动速度的影响,以大连玉华220kV线路新建工程2#大里程隧道为例,分析周边孔爆破振动信号。2#大里程隧道临近商业建筑,通过掏槽孔、周边孔两次起爆,达到了控制爆破振速的目的。因此,在爆破断面垂直的商铺附近,距离爆破断面约6m处布置测试点进行监测。采用FFT法、小波包分析法、加速度功率谱密度法对爆破的振动速度、持续时间、主频、能量-频率分布等进行了分析。结果发现:周边孔爆破中距爆破断面水平距离6m处的最大单向振动速度为1.122 4cm/s,频率较高,80Hz以上,在《爆破安全规程》规定的振动速度范围之内。同时分析了3种方法的异同点,FFT法的速度谱与小波包分析的能量-频谱图波形相似,主频与小波包分析法相差不大,与加速度功率谱密度计算的主频非常接近,可用FFT法初步分析爆破振动信号的能量分布比例。小波包分析法在主频确定方面有更高的分辨率,在精细分析时应采用小波包分析法进行爆破振动信号的分析。该爆破振动信号分析对有效地控制振动速度,降低爆破对周边建筑物的损害和爆破网路设计有着很好的指导意义。
In order to find out the influence of periphery hole blasting on controling blasting vibration velocity,the blasting signal of periphery hole was analysized,which was based on the New Construction of Dalian Yuhua 220 kV transmission line.The section of 2# shaft is closed to commercial building,the blasting vibration velocity was controlled effectively by initiation of cutting hole and periphery hole orderly.The blasting signal was measured at the commercial building which is about 6 maway from blasting section.The vibration velocity,duration,dominant frequency,energy-frequency distribution in the blasting vibration signal were analyzed by FFT method,wavelet packet analysis method and acceleration power spectrum density method.The results indicated that the maximum single direction velocity of the measure point was 1.122 4 cm/s,where is 6 mhorizontal distance from blasting section in periphery hole blast.The frequency was high,higher than 80 Hz,and the velocity was satisfied with the standard of "Safety Regulations for Blasting".At the same time,the similarities and differences of the three methods were analyzed.The FFT spectrum of velocity and energy spectrum of blasting vibration signal calculated by wavelet packet analysis were similar,and it had little difference in calculation of dominant frequency with wavellet packet analysis and very closed to that of acceleration power spectral density.The FFT method can be used to calculated the dominant frequency and evaluated the proportion of energy distribution of vibration signal roughly and rapidly.The wavelet packet analysis method had a high accuracy in calculating dominant frequency,and wavelet packet analysis method was a best choice to precess signal in the case of high precision.The blasting vibration signal analysis has a good guiding significance for the blasting network design,which can effectively control the vibration speed and reduce the damage to the surrounding buildings by blasting.

关键词(KeyWords)： 爆破振动;小波包分析;加速度功率谱密度;周边孔
blasting vibration;wavelet packet analysis;acceleration power spectral density;periphery hole

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(11672068;11672067;10872044;10902023)

作者(Authors): 赵铁军;姜殿科;周明;高蔚;闫鸿浩;
ZHAO Tie-jun;JIANG Dian-ke;ZHOU Ming;GAO Wei;YAN Hong-hao;Department of Engineering Mechanics,Dalian University of Technology;State Grid Liaoning Electric Power Supply Co.,Ltd.,Dalian Power Supply Company;

参考文献(References)：

• [1]朱权洁,姜福兴,于正兴,等.爆破震动与岩石破裂微震信号能量分布特征研究[J].岩石力学与工程学报,2012(4):723-730.ZHU Q J,JIANG F X,YU Z X,et al.Study on energy distribution characters about blasting vibration and rock fracture microseismic signal[J].Chinese Journal of Rock Mechanics and Engineering,2012(4):723-730.
• [2]周俊汝,卢文波,张乐,等.爆破地震波传播过程的振动频率衰减规律研究[J].岩石力学与工程学报,2014(11):2 171-2 178.ZHOU J R,LU W B,ZHANG L,et al.Attenuation of vibration frequency during propagation of blasting seismic wave[J].Chinese Journal of Rock Mechanics and Engineering,2014(11):2 171-2 178.
• [3]傅洪贤,赵勇,谢晋水,等.隧道爆破近区爆破振动测试研究[J].岩石力学与工程学报,2011(2):335-340.FU H X,ZHAO Y,XIE J S,et al.Study on blasting vibration test of area near tunnel blasting source[J].Chinese Journal of Rock Mechanics and Engineering,2011(2):335-340.
• [4]李洪涛,卢文波,舒大强,等.基于功率谱的爆破地震能量分析方法[J].爆炸与冲击,2009(5):492-496.LI H T,LU W B,SHU D Q,et al.An energy analysis method for blast-induced seismic based on power spectrum[J].Explosion and Shock Waves,2009(5):492-496.
• [5]闫长斌,王贵军,石守亮,等.岩体爆破损伤声波测试信号频谱特征的小波(包)分析[J].岩石力学与工程学报,2010(7):1 496-1 502.YAN C B,WANG G J,SHI S L,et al.Analysis of acoustic wave frequency spectrum characters of rock mass under blasting damage based on wavelet(packet)transformation[J]Chinese Journal of Rock Mechanics and Engineering,2010(7):1 496-1 502.
• [6]凌同华,李夕兵.多段微差爆破振动信号频带能量分布特征的小波包分析[J].岩石力学与工程学报,2005(7):1 117-1 122.LING T H,LI X B.Analysis of energy distributions of millisecond blast vibration signals using the wavelet packet method[J].Chinese Journal of Rock Mechanics and Engineering,2005(7):1 117-1 122.
• [7]凌同华,李夕兵.爆破振动信号不同频带的能量分布规律[J].中南大学学报(自然科学版),2004(2):310-315.LING T H,LI X B.Laws of energy distribution in different frequency bands for blast vibration signals[J].J.Cent.South Univ.(Natural Science),2004(2):310-315.
• [8]何理,钟冬望,刘建程,等.微差爆破试验及爆破振动能量的小波包分析[J].金属矿山,2014(6):10-15.HE L,ZHONG D W,LIU J C,et al.Millisecond blasting tests and wavelet packet analysis of blasting vibration energy[J].Metal Mine,2014(6):10-15.
• [9]贾秋燕,盛侃.航空产品运输模拟试验结果的测量不确定度评估[J].航空精密制造技术,2015(1):15-18.JIA Q Y,SHENG K.Evaluation of uncertainty about aviation product transport simulation test results[J].Aviation Precision Manufacturing Technology,2015(1):15-18.
• [10]闫鸿浩,浑长宏,李晓杰,等.复杂爆破作业环境下的加速度功率谱密度分析[J].振动与冲击,2017(3):113-118.YAN H H,HUN C H,LI X J,et al.Blasting vibration acceleration power spectral density analysis under complex blasting operation environment[J].Journal of Vibration and Shock,2017(3):113-118.
• [11]闫鸿浩,浑长宏,李晓杰,等.加速度功率谱密度指标控制下的爆破研究[J].岩石力学与工程学报,2016(S2):4 180-4 186.YAN H H,HUN C H,LI X J,et al.Research on blasting under the controlled of acceleration power spetrum density index[J].Chinese Journal of Rock Mechanics and Engineering,2016(S2):4 180-4 186.
• [12]范顺庭.用快速富里叶变换计算海浪的功率谱密度函数[J].海洋湖沼通报,1979(2):6-11.FAN S T.The evaluating method of wave power spectral density function with fast fourier transform[J].Transactions of Oceanology and Limnology,1979(2):6-11.
• [13]汪凤泉,郑万泔.试验振动分析[M].南京:江苏科学技术出版社,1988.WANG F Q,ZHENG W G.Test vibration analysis[M].Nanjing:Jiangsu Science and Technology Press,1988.
• [14]闫鸿浩,杨瑞,李晓杰,等.地铁隧道浅埋段下穿砖混结构房屋爆破振动控制研究[J].施工技术,2016(S1):422-427.YAN H H,YANG R,LI X J,et al.Control of blasting vibration in shallow depth tunnel construction under brick and concrete residential buildings[J].Construction Technology,2016(S1):422-427.
• [15]张蓉竹,蔡邦维,杨春林,等.功率谱密度的数值计算方法[J].强激光与粒子束,2000(6):661-664.ZHANG R Z,CAI B W,YANG C L,et al.Numerical method of the power spectral density[J].High Power Laser and Particle Beams,2000(6):661-664.
• [16]宁瑞峰,张世平.小波包分析在爆破震动信号能量衰减规律中的应用[J].爆破,2014(1):1-4,37.NING R F,ZHANG S P.Application of wavelet packet analysis in blasting vibration signal energy attenuation law[J].Blasting,2014(1):1-4,37.
• [17]中国生,房营光,徐国元,等.基于小波包分析的建(构)筑物爆破振动安全判据研究[J].岩土工程学报,2009(2):223-228.ZHONG G S,FANG Y G,XU G Y,et al.Safety criterion of blasting vibration for structure based on wavelet packet analysis[J].Chinese Journal of Geotechnical Engineering,2009(2):223-228.
• [18]国家安全生产监督管理总局.爆破安全规程:GB 6722-2014[S].北京:中国标准出版社,2015.State Administration of Work Safety.Safety regulations for blasting:GB 6722-2014[S].Beijing:China Standards Press,2015.