王海亮;高尚;张海义;
WANG Hai-liang;GAO Shang;ZHANG Hai-yi;College of Safety and Environmental Engineering, Shandong University of Science and Technology;Sangshuping Coal Mine, Shaanxi Coal Hancheng Mining Co., Ltd.;

• 1:山东科技大学安全与环境工程学院
• 2:陕西陕煤韩城矿业有限公司桑树坪煤矿

摘要(Abstract)：

为探究地应力和侧压力系数对爆破损伤范围及损伤分布的影响，基于RHT本构建立双孔爆破模型，运用LS-DYNA软件对不同地应力水平下的岩石爆破进行了数值模拟，对裂隙的扩展、贯通过程进行了分析，研究了高地应力对爆破损伤演化的影响。研究表明：裂隙区比粉碎区对地应力的变化更敏感，地应力对裂隙区的发育特别是主裂隙的扩展起抑制作用；随着静水地应力的增加，粉碎区和裂隙区范围、主裂隙长度逐渐减小，岩石破碎和裂隙贯通愈发困难；非静水应力下，最大主应力对裂隙扩展具有导向作用，侧压力系数越大，岩石损伤各向异性越明显；根据高地应力岩石损伤特性提出了爆破优化措施。
To explore the influence of in-situ stress and lateral stress coefficients on blasting damage range and distribution, the double hole blasting model was established based on RHT constitutive model. The numerical simulation of rock double-hole blasting under different in-situ stress levels was carried out by LS-DYNA software. This paper analyzes the process of blasting crack propagation and penetration, and focuses on the influence of high in-situ stress on blasting damage evolution. The research shows that the fracture zone is more sensitive to the change of in-situ stress than the crushing zone, and the in-situ stress inhibits the development of the fracture zone, especially the expansion of the main fracture. With the increase of hydrostatic in-situ stress, the range of crushing zone and fracture zone and the length of main fracture gradually decrease, and it is more and more difficult for rock fragmentation and fracture penetration. Under the non-hydrostatic in-situ stress, the maximum principal stress has a guiding effect on crack propagation. The anisotropy of rock damage becomes more obvious with the increase of lateral stress coefficient. In addition, several blasting optimization measures are proposed according to the damage characteristics of high ground stress rock.

关键词(KeyWords)： 双孔爆破;损伤演化;高地应力;侧压力系数
double-hole blasting;damage evolution;high in-situ stress;lateral stress coefficient

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(10672091)

作者(Authors): 王海亮;高尚;张海义;
WANG Hai-liang;GAO Shang;ZHANG Hai-yi;College of Safety and Environmental Engineering, Shandong University of Science and Technology;Sangshuping Coal Mine, Shaanxi Coal Hancheng Mining Co., Ltd.;

DOI: 10.19931/j.eb.20210215

参考文献(References)：

• [1] 周林生，樊克恭，刘军，等.冲击地压工作面爆破卸压效果的数值模拟[J].山东科技大学学报(自然科学版),2005,24(4):77-80.ZHOU L S,FAN K G,LIU J,et al.Numerical simulation of blasting pressure relief effect in working face with rock burst[J].Journal of Shandong University of Science and Technology (Natural science),2005,24(4):77-80.
• [2] 赵建平，程贝贝，卢伟，等.深部高地应力下岩石双孔爆破的损伤规律[J].工程爆破，2020,26(5):14-20.ZHAO J P,CHENG B B,LU W,et al.Damage law of rock double holes blasting under deep high in-situ stress [J].Engineering Blasting,2020,26(5):14-20.
• [3] 刘伟，张伟，陈士海.深部岩石巷道爆破卸荷的破裂范围研究[J].山东科技大学学报(自然科学版),2013,32(2):66-70.LIU W,ZHANG W,CHEN S H.Research on the fracture range of deep rock roadway blasting unloading [J].Journal of Shandong University of Science and Technology (Natural science),2013,32(2):66-70.
• [4] 王汉军，杨仁树，李清.深部岩巷爆破机理分析和爆破参数设计[J].煤炭学报，2007(4):373-376.WANG H J,YANG R S,LI Q.Analysis of blasting mechanism and design of blasting parameters in deep rock tunnels [J].Journal of China Coal Society,2007(4):373-376.
• [5] OZGUR Y,TUGRUL U.Three dimensional numerical rock damage analysis under blasting load[J].Tunnelling and Underground Space Technology,2013(38):266-278.
• [6] XIE L X,LU W B,ZHANG Q B.Analysis of damage mechanisms and optimization of cut blasting design under high in-situ stresses[J].Tunnelling and Underground Space Technology,2017(66):19-33.
• [7] 江成，甯尤军，武鑫.地应力条件下的凿岩爆破数值模拟[J].工程爆破，2017,23(1):16-20.JIANG C,NING Y J,WU X.Numerical simulation of drilling blasting under earth stress[J].Engineering Blasting,2017,23(1):16-20.
• [8] 郭双，武鑫，甯尤军.地应力条件下爆破载荷破岩的DDA模拟研究[J].工程爆破，2018,24(5):8-14.GUO S,WU X,NING Y J.DDA simulations of rock fracture by blasting loads under geostress conditions [J].Engineering Blasting,2018,24(5):8-14.
• [9] DING C X,YANG R S,YANG L Y.Experimental results of blast-induced cracking fractal characteristics and propagation behavior in deep rock mass[J].International Journal of Rock Mechanics and Mining Sciences,2021(142):10.1016/J.IJRMMS.2021.104772.
• [10] WANG Z L,WANG H C,WANG J G.Finite element analyses of constitutive models performance in the simulation of blast-induced rock cracks[J].Computers and Geotechnics,2021(135):10.1016/J.COMPGEO.2021.104172.
• [11] 黄佑鹏.基于HJC本构的岩石爆破损伤演化规律数值模拟[D].合肥：合肥工业大学，2020.HUANG Y P.Numerical simulation of rock blasting damage evolution based on HJC constitutive model [D].Hefei:Hefei University of Technology,2020.
• [12] HE C L,YANG J.Experimental and numerical investigations of dynamic failure process in rock under blast loading[J].Tunnelling and Underground Space Technology,2018(83):552-564.
• [13] 于广明，潘永战，王国艳.岩石损伤协同特征分析[J].山东科技大学学报(自然科学版),2009,28(4):5-8.YU G M,PAN Y Z,WANG G Y.Analysis of synergistic characteristics of rock damage [J].Journal of Shandong University of Science and Technology (Natural science),2009,28(4):5-8.
• [14] JAYASINGHE L B,SHANG J L,ZHAO Z Y.Numerical investigation into the blasting-induced damage characteristics of rocks considering the role of in-situ stresses and discontinuity persistence[J].Computers and Geotechnics,2019(116):103207.
• [15] YI C P,DANIEL J,JENNY G.Effects of in-situ stresses on the fracturing of rock by blasting[J].Computers and Geotechnics,2017(104):321-330.