熊凌浩,周传波,蒋楠,王腾,蒙贤忠
XIONG Ling-hao,ZHOU Chuan-bo,JIANG Nan,WANG Teng,MENG Xian-zhong

• 1:中国地质大学(武汉)工程学院

摘要(Abstract)：

大断面隧道新浇二衬混凝土的强度较低，在爆破施工过程中易受到破坏。为研究新浇二衬混凝土爆破振动控制标准，结合大断面龙南隧道工程，采用现场监测与数值模拟相结合的研究方法，分析不同龄期大断面隧道新浇二衬混凝土在爆破振动作用下的动力响应特征，得出新浇二衬混凝土爆破振动控制安全阈值。研究结果表明：隧道二衬拱顶z方向振动速度和拉应力大于其他部位，峰值振动速度6.66 cm/s和峰值拉应力1.57 MPa出现在拱顶，拱顶是最危险位置；不同龄期下二衬拱顶的爆破振动速度随爆心距的增大呈指数衰减趋势，随着混凝土龄期的增加而衰减，且不同方向衰减趋势有差异；基于数值模拟结果和动态抗拉强度理论，大断面龙南隧道新浇二衬混凝土爆破安全振动速度阈值为2.80 cm/s。
The strength of newly poured secondary lining concrete in large section tunnel is low, which is easy to be damaged during blasting construction. In order to study the blasting vibration control standard of newly poured secondary lining concrete, combing the large section Longnan tunnel project, field monitoring and numerical simulation were adopted to analyze the dynamic response characteristics of newly poured secondary lining concrete under blasting vibration in large section tunnels of different ages, and the safety threshold of blasting vibration control of newly poured secondary lining concrete were obtained. The results show that the vibration velocity and tensile stress in the z direction of the tunnel secondary lining vault are greater than those in other parts. The peak vibration velocity of 6.66 cm/s and the peak tensile stress of 1.57 MPa appear in the vault, and the vault is the most dangerous position; Under different ages, the blasting vibration velocity of the secondary lining vault decreases exponentially with the increase of blasting center distance, and decreases with the increase of concrete age, and the attenuation trend is different in different directions; Based on the numerical simulation results and dynamic tensile strength theory, the safe vibration velocity threshold of blasting vibration of newly cast secondary lining concrete in Longnan tunnel with large section is 2.80 cm/s.

关键词(KeyWords)： 爆破振动;隧道二衬;新浇混凝土;安全振动速度
blasting vibration;tunnel secondary lining;newly concrete;safe vibration speed

Abstract:

Keywords:

基金项目(Foundation): 国家自然科学基金资助项目(41972286)

作者(Author): 熊凌浩,周传波,蒋楠,王腾,蒙贤忠
XIONG Ling-hao,ZHOU Chuan-bo,JIANG Nan,WANG Teng,MENG Xian-zhong

DOI: 10.19931/j.EB.20210239

参考文献(References)：

• [1] 田振农，张乐文.岩体中软弱夹层影响爆炸波传播规律的数值分析[J].沈阳工业大学学报，2010,32(3):349-354.TIAN Z N,ZHANG L W.Numerical analysis of blast wave propagation in rock masscontaining weak interlayer[J].Journal of Shenyang University of Technology,2010,32(3):349-354.
• [2] 谢烽.施工隧道内部爆破振动效应研究[D].北京：中国矿业大学(北京),2017.XIE F.Study on vibration effect of blasting inside the construction tunnel[D].Beijing:China University of Mining & Technology(Beijing),2017.
• [3] 张庆松，李利平，李术才，等.小间距隧道爆破动力特性试验研究[J].岩土力学，2008,29(10):2 655-2 660.ZHANG Q S,LI L P,LI S C,et al.Experimental study of blasting dynamic vibration of closely adjacent tunnels[J].Rock and Soil Mechanics,2008,29(10):2 655-2 660.
• [4] 王后裕，刘志杰，杨铁昌，等.地下工程改扩建中施工爆破对衬砌危害的三维数值模拟研究[J].振动与冲击，2007,26(6):74-78.WANG H Y,LIU Z J,YANG T C,et al.Three dimensional numerical analysis on damage of lining subjected to blasting loads during underground cavern enlarging [J].Journal of Vibration and Shock,2007,26(6):74-78.
• [5] 刘庭金，朱合华，丁文其.某高速公路隧道二次衬砌安全性分析[J].岩石力学与工程学报，2004(1):75-78.LIU T J,ZHU H H,DING W Q,et al.Safety analysis of secondary lining of a freeway tunnel[J].Chinese Journal of Rock Mechanics and Engineering,2004(1):75-78.
• [6] 闫军，杜峰，李仲来.邻近隧道二衬结构在爆破振动作用下的动态响应测试研究[J].中外公路，2017,37(1):184-187.YAN J,DU F,LI Z L,et al.Test and research on dynamic response of secondary lining structure of adjacent tunnel under blasting vibration[J].Journal of China & Foreign Highway,2017,37(1):184-187.
• [7] 邓涛，李先章，章仕灵，等.基于爆破振速控制下的掌子面与二次衬砌安全距离研究[J].铁道建筑，2013(4):54-57.DENG T,LI X Z,ZHANG S L,et al.Study on safety distance between tunnel face and secondary lining based on blasting vibration speed control[J].Railway Engineering,2013(4):54-57.
• [8] 邵东辉.隧道掘进爆破下新浇二次衬砌的动力特性[J].工程爆破，2017,23(3):47-51,72.SHAO D H,Dynamic characteristics of newly-poured secondary lining in tunnl development blasting[J].Engineering Blasting,2017,23(3):47-51,72.
• [9] 蒋楠，周传波，罗钢，等.铁路隧道混凝土衬砌爆破振动安全判据[J].中南大学学报(自然科学版),2012,43(7):2 746-2 750.JIANG N,ZHOU C B,LUO G,et al.Blasting vibration safety criterion of railway tunnel concrete lining[J].Journal of Central South University(Science and technology) ,2012,43(7):2 746-2 750.
• [10] 孔德森，孟庆辉，张伟伟，等.爆炸荷载作用下地铁隧道的冲击反应研究[J].振动与冲击，2012,31(12):68-72.KONG D S,MENG Q H,ZHANG W W,et al.Shock responses of a metro tunnel subjected to explosive loads[J].Journal of Vibration and Shock,2012,31(12):68-72.
• [11] LIU Z,JIANG N,SUN J,et al.Influence of tunnel blasting construction on adjacent highway tunnel:A case study in Wuhan,China[J].International Journal of Protective Structures,2020,11(3):283-303.
• [12] 李毅敏，高政国，朱庆庆，等.爆破冲击对早龄期混凝土强度影响的实验研究[J].爆炸与冲击，2013,33(3):243-248.LI Y M,GAO Z G,ZHU Q Q,et al.An experimental investigation into effects of blast-induced vibration on strength of early-age concrete[J].Explosion and Shock Waves,2013,33(3):243-248.
• [13] 严鹏，李涛，卢文波，等.深埋隧洞爆破开挖荷载诱发围岩损伤特性[J].岩土力学，2013,34(S1):451-457.YAN P,LI T,LI W B,et al.Properties of excavation damaged zone under blasting load in deep tunnels [J].Rock and Soil Mechanics,2013,34(S1):451-457.
• [14] 杨建华，卢文波，陈明，等.岩石爆破开挖诱发振动的等效模拟方法[J].爆炸与冲击，2012,32(2):157-163.YANG J H ,LU W B,CHEN M,et al.An equivalent simulation method for blasting vibration of surrounding rock [J].Blasting and Shock Waves,2012,32(2):157-163.
• [15] 王明洋，邓宏见，钱七虎.岩石中侵彻与爆炸作用的近区问题研究[J].岩石力学与工程学报，2005,24(16):2 859-2 863.WANG M Y,DENG H J,QIAN Q H.Study on problems of near cavity of penetration and explosion in rock [J].Chinese Journal of Rock Mechanics and Engineering,2005,24(16):2 859-2 863.
• [16] ESEN S,ONEDERRA I,BILGIN H A.Modelling the size of the crushed zone around a blasthole [J].International Journal of Rock Mechanics & Mining Sciences,2003,40(4):485-495.
• [17] 易长平.爆破振动对地下洞室的影响研究[D].武汉：武汉大学，2005.YI C P.The influence of blasting vibration on underground chambers [D].Wuhan:Wuhan University,2005.
• [18] 王鹏，周传波，耿雪峰，等.多孔同段爆破漏斗形成机理的数值模拟研究[J].岩土力学，2010,31(3):993-997.WANG P,ZHOU C B,GENG X F,et al.Numerical simulation of formation mechanism of multi hole and same delay time of blasting crater[J].Rock and Soil Mechanics,2010,31(3):993-997.
• [19] 杨光.隧道爆破施工对邻近既有隧道结构安全的影响分析与控制研究[D].长沙：中南大学，2011.YANG G.Control and analysis of an existing tunnel vibration induced by blasting construction of nearby tunnel[D].Changsha:Central South University,2011.
• [20] 刘宏伟，谢丽，吴胜兴.混凝土早龄期弹性模量无损检测初探[J].混凝土，2008(6):36-38.LIU H W,XIE L,WU S X.Tentative research on non-destructive detection of early-age elastic modulus of concrete[J].Concrete,2008(6):36-38.
• [21] 国家安全生产管理监督总局.爆破安全规程：GB 6722-2014[S].北京：中国标准出版社，2015.State Administration of Work Safety.Safety regulations for blasting.GB 6722-2014[S].Beijing:China:China Standard Press,2015.
• [22] 王明洋，周泽平，钱七虎，等.深部岩体的构造和变形与破坏问题[J].岩石力学与工程学报，2006(3):448-455.WANG M Y,ZHOU Z P,QIAN Q H,et al.Tectonic,deformation and failure problems of deep rock mass[J].Chinese Journal of Rock Mechanics and Engineering,2006(3):448-455.
• [23] 国家铁路局.铁路隧道设计规范：TB 10003-2016[S].北京：中国标准出版社，2016.National Railway Administration.Code for design of railway tunnel:TB 10003—2016[S].Beijing:China Standard Press,2016.