赵瑞玺;
ZHAO Rui-xi;Explosive Plant of Shenhua Zhungeer Energy Co.,Ltd.;

• 1:神华准格尔能源有限责任公司炸药厂

摘要(Abstract)：

为了控制黑岱沟露天矿煤层爆破中1.8m以上大块的产出率和10mm粒度以下煤的产率,提高优质煤的块煤率和产量,在分析煤岩爆破破碎机理及减少爆破药柱粉碎区途径的过程中,对爆破参数进行了优化,提出了将低密度铵油炸药应用于黑岱沟露天煤矿煤层爆破的方案。同时,对低密度铵油炸药和铵油炸药不同孔网参数、装药结构、填塞长度进行煤层爆破对比实验,分析了二者对块煤率、采掘效率及安全性的影响。结果表明:低密度铵油炸药能够实现炮孔内连续装药,其线装药密度低,有利于降低炸药单耗,爆炸能量传递更均匀,能有效减少末煤量,块煤率较铵油炸药提高了13.78%。确定了露天煤矿厚煤层爆破炸药单耗的最佳范围是0.176⁰.23kg/m3,可为露天煤矿煤层爆破设计提供依据。
In order to control the output of large blocks of more than 1.8 min coal seam blasting,the yield of coal below 10 mm in Heidaigou open pit coal mine,improve the quality of coal lump coal rate and output,by analyzing the mechanism of coal rock burst breaking and ways to reduce to crush the area of the blasting,blasting parameters are optimized and a scheme was proposed to apply low density ammonium oil explosives to coal seam blasting in Heidaigou open pit coal mine.At the same time,by the comparison test of low-density explosives and ammonium oil explosives of different hole network parameters,charge structure and filling height,the impact of mining efficiency,lump coal rate and safety are analyzed.The results show that low-density explosives can realize continuous charging in the blasthole,the low density of line charge is good for reducing unit explosive consumption,explosion energy transfer more evenly and it can effectively reduce the amount of foam coal and lump coal rate increases by 13.78% higher than ammonium oil explosives.The optimal range of the unit explosive consumption is 0.1760.23kg/m3,可为露天煤矿煤层爆破设计提供依据。
In order to control the output of large blocks of more than 1.8 min coal seam blasting,the yield of coal below 10 mm in Heidaigou open pit coal mine,improve the quality of coal lump coal rate and output,by analyzing the mechanism of coal rock burst breaking and ways to reduce to crush the area of the blasting,blasting parameters are optimized and a scheme was proposed to apply low density ammonium oil explosives to coal seam blasting in Heidaigou open pit coal mine.At the same time,by the comparison test of low-density explosives and ammonium oil explosives of different hole network parameters,charge structure and filling height,the impact of mining efficiency,lump coal rate and safety are analyzed.The results show that low-density explosives can realize continuous charging in the blasthole,the low density of line charge is good for reducing unit explosive consumption,explosion energy transfer more evenly and it can effectively reduce the amount of foam coal and lump coal rate increases by 13.78% higher than ammonium oil explosives.The optimal range of the unit explosive consumption is 0.176⁰.23 kg/m3 in open pit coal thick seam and it provides the basis for coal seam blasting design in open pit coal mine.

关键词(KeyWords)： 露天煤矿;块煤率;参数优化;爆破实验
open pit coal mine;lump coal rate;parameters optimization;blasting experiment

Abstract:

Keywords:

基金项目(Foundation):

作者(Authors): 赵瑞玺;
ZHAO Rui-xi;Explosive Plant of Shenhua Zhungeer Energy Co.,Ltd.;

参考文献(References)：

• [1]张勇.黑岱沟露天煤矿高台阶抛掷爆破分析[J].露天采矿技术,2008(5):43-44.ZHANG Y.Analysis of high bench casting blast analysis for Heidaigou open pit coal mine[J].Opencast Mining Technology,2008(5):43-44.
• [2]赵瑞玺.改进爆破技术提高块煤率[J].露天采煤技术,2000(3):25-28.ZHAO R X.Improvement of blasting technique to improve the lump coal rate[J].Opencast Mining Technology,2000(3):25-28.
• [3]李玉清,宋日,李渊,等.露天矿高台阶抛掷爆破炸药配方设计及制备[J].爆破器材.2013,42(3):37-40.LI Y Q,SONG R,LI Y,et al.Design and on site preparation of explosive used for high step casting blast in open-pit mine[J].Explosive Materials,2013,42(3):37-40.
• [4]安玉岳,谢武化,胡海云.高台阶预裂爆破应用低密度铵油炸药经济技术分析[J].中小企业管理与科技,2015(10):259-261.AN Y Y,XIE W H,HU H Y.Economic and technical analysis of the application of low density ammonite explosive in high stage presplitting blasting[J].Management&Technology of SME,2015(10):259-261.
• [5]宋日.露天煤矿抛掷爆破缓冲孔爆破优化与效益分析[J].工程爆破,2016,22(2):34-37.SONG R.Open-pit coal mine design optimization of casting blast delay punching and benefit analysis[J].Engineering Blasting,2016,22(2):34-37.
• [6]吕春绪.工业炸药理论[M].北京:兵器工业出版社,2003:177-178.LYU C X.Theory of Industrial Explosive[M].Beijing:Ordnance Industry Press,2003:177-178.
• [7]姬长生,马军.黑岱沟露天煤矿开采工艺的理论与实践[M].徐州:中国矿业大学出版社,2010.JI C S,MA J.Theory and practice of mining technology in heidaigou open-pit coal mine[M].Xuzhou:China University of Mining and Technology Press,2010.
• [8]郭昭华.露天煤矿无运输倒堆开采技术及应用研究[M].北京:煤炭工业出版社,2012:111-174.GUO Z H.Study and application of the technology for no transport and dragline in open pit coal mine[M].Beijing:China Coal Industry Publishing Press,2012:111-174.
• [9]于亚伦.工程爆破理论与技术[M].北京:冶金工业出版社,2007.YU Y L.Engineering blasting theory and technology[M].Beijing:Metallurgical Industry Press,2007.
• [10]黄绍钧.工程爆破设计[M].北京:兵器工业出版社,2000.HUANG S J.Engineering blasting design[M].Beijing:Weaponry Industry Press,2000.