张凯;何毅;张红峰;刘晓强;代建;陈云;
ZHANG Kai;HE Yi;ZHANG Hong-feng;LIU Xiao-qiang;DAI Jian;CHEN Yun;Shanxi Jiangyang Engineering Blasting Co.,Ltd.;

• 1:山西江阳工程爆破有限公司

摘要(Abstract)：

炮孔内柱状不耦合装药结构可以显著降低炸药单耗和矿岩大块率,这种爆破装药结构在工程爆破中广泛使用。为了在此装药结构基础上继续降低矿岩大块率,采用AUTODYN有限元软件,研究了相邻炮孔间隔柱对称与交错布置的不同组合方式对爆破效果的影响。模拟研究表明,相邻炮孔间隔柱交错布置时岩体内应力峰值相对小且分布更均匀,被爆岩体的初始压力峰值相对小,避免了岩体的过度粉碎,同时其峰值衰减更慢,延长了被爆岩体所受应力的有效作用时间,提高了炸药能量利用率。通过对采场试爆数据分析,表明相邻炮孔内间隔柱采用交错布置后,大块率减小,块度更加集中,直径为0¹5cm的矿岩块度比例提高了约4%,平均块度大小较间隔柱对称布置方式降低了约15%。
The column uncoupled charge structure can significantly reduce the consumption of explosives and the mass rate of ore and rock.This explosive charge structure is widely used in engineering blasting.In order to reduce the rock mass rate again on the basis of the charge structure,the influence of two different combinations of the adjacent hole spaces column symmetry and interlaced arrangement on the blasting effect is studied by the AUTODYN finite element software.The simulation results show that the peak value of stress in the rock mass is relatively small and the distribution is more uniform when the adjacent blast hole spaces column is staggered.The initial pressure peak value of the blasting rock mass is relatively small,which avoids the excessive crushing of the rock mass,at the same time,the peak attenuation is slower,and the effective time of stress of the blasting rock mass is prolonged,the energy utilization rate of explosives is improved.Based on the analysis of pre-blasting test data,it is shown that after interlaced arrangement of adjacent blast holes,the mass rate decreases and the block size is more concentrated.The rock mass ratio of diameter 015cm的矿岩块度比例提高了约4%,平均块度大小较间隔柱对称布置方式降低了约15%。
The column uncoupled charge structure can significantly reduce the consumption of explosives and the mass rate of ore and rock.This explosive charge structure is widely used in engineering blasting.In order to reduce the rock mass rate again on the basis of the charge structure,the influence of two different combinations of the adjacent hole spaces column symmetry and interlaced arrangement on the blasting effect is studied by the AUTODYN finite element software.The simulation results show that the peak value of stress in the rock mass is relatively small and the distribution is more uniform when the adjacent blast hole spaces column is staggered.The initial pressure peak value of the blasting rock mass is relatively small,which avoids the excessive crushing of the rock mass,at the same time,the peak attenuation is slower,and the effective time of stress of the blasting rock mass is prolonged,the energy utilization rate of explosives is improved.Based on the analysis of pre-blasting test data,it is shown that after interlaced arrangement of adjacent blast holes,the mass rate decreases and the block size is more concentrated.The rock mass ratio of diameter 0¹5 cm increased by about 4%,the average block size is reduced by about 15% compared with the symmetrical arrangement of the spaces.

关键词(KeyWords)： 爆破;空气间隔柱;AUTODYN软件;相邻炮孔;爆破效果
blasting;air spacer column;AUTODYN software;adjacent holes;blasting effect

Abstract:

Keywords:

基金项目(Foundation):

作者(Authors): 张凯;何毅;张红峰;刘晓强;代建;陈云;
ZHANG Kai;HE Yi;ZHANG Hong-feng;LIU Xiao-qiang;DAI Jian;CHEN Yun;Shanxi Jiangyang Engineering Blasting Co.,Ltd.;

参考文献(References)：

• [1]王旭,唐绍辉,潘懿,等.袁家村铁矿空区治理爆破参数优化及方案验证[J].爆破,2017,34(1):67-72.WANG X,TANG S H,PAN Y,et al.Optimization and program validation of blasting parameters for empty area treatment in Yuanjia village iron ore mine[J].Blasting,2017,34(1):67-72.
• [2]王凯,张智宇,高腾飞.某露天采场深孔台阶爆破空气间隔装药的应用[J].爆破,2018,35(1):80-85.WANG K,ZHANG Z Y,GAO T F.Application of air interval charge for deephole bench blasting in an open pit mine[J].Blasting,2018,35(1):80-85.
• [3]吴亮,位敏,钟冬望,等.空气间隔装药爆破动态应力场特性研究[J].爆破,2009,26(4):17-21.WU L,WEI M,ZHONG D W,et al.Study on dynamic stress field characteristics of air interval charge blasting[J].Blasting,2009,26(4):17-21.
• [4]刘超.炮孔空气间隔装药爆破技术研究[D].长沙:长沙矿山研究院,2017:20-25.LIU C.Research on air gap charging blasting technology[D].Changsha:Changsha Institute of Mining Research,2017:20-25.
• [5]罗强.装药结构对岩体内爆炸应力场的影响研究[D].淮南:安徽理工大学,2006:15-30.LUO Q.Study on the influence of blast stress field in rock mass due to modification of charge structure[D].Huainan:Anhui University of Science and Technology,2006:15-30.
• [6]丁光亚,徐颖,熊楚明.岩石中相邻炮孔装药爆破的数值模拟[J].安徽理工大学学报(自然科学版),2004(S1):56-59.DING G Y,XU Y,XIONG C M.Numerical simulation of charge blasting of adjacent hole in rock[J].Journal of Anhui University of Science and Technology(Natural Science Edition),2004(S1):56-59.
• [7]李祥龙,张松涛,李明扬,等.基于AUTODYN的岩石中爆炸鼓包运动模拟[J].煤炭学报,2016,41(S2):419-424.LI X L,ZHANG S T,LI M Y,et al.AUTODYN based simulation of explosion in a rock[J].Chinese Journal of Coal,2016,41(S2):419-424.
• [8]周青青.基于ANSYS预裂爆破装药结构研究[D].贵阳:贵州大学,2015:30-35.ZHOU Q Q.Study on charge structure of pre splitting blasting based on ANSYS[D].Guiyang:Guizhou University,2015:30-35.